PURSUIT 2460 Denali Manuale del Proprietario

2460 Denali2460 DENALIOWNER’S MANUAL FISHING BOATS3901 St. Lucie Blvd.Ft. Pierce, Florida 34946Print Date 2/2000

2460 DenaliS2 Yachts will confirm, in writing, that the transfer of the warranty has taken place. After which,the transferee will be treated as the o

2460 DenaliChrome HardwareUse a good chrome cleaner and polish on all chrome hardware.Acrylic Plastic GlassAcrylic plastic glass scratches easily. Us

2460 Denali13.2 Upholstery, Canvas and EnclosuresVinyl UpholsteryThe vinyl upholstery used on the exterior seats and bolsters, and for the headliner i

2460 DenaliDO NOT USE ANY POLISH CONTAINING LEMON SCENTS OR LEMON. THE LEMONJUICE WILL ATTACK THE VINYL AND SHORTEN ITS LIFE.Snaps should be lubricat

2460 Denali13.4 Bilge and Engine CompartmentTo keep the bilge clean and fresh, use a commercial bilge cleaner regularly. Follow the directionscareful

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter 14:SEASONAL MAINTENANCE14.1 Lay-up and StorageBefore Hauling• Pump out the head. Flush the holding tank using clean soap, water a

2460 DenaliLiftingBOATS HAVE BEEN DAMAGED FROM IMPROPER LIFTING AND ROUGH HANDLINGWHEN BEING TRANSPORTED BY LIFT TRUCKS. CARE AND PROPER HANDLING PRO

2460 Denali• Make sure the outdrive is in the down position.• The cradle must be in the proper fore and aft position to properly support the hull. Wh

2460 Denali14.2 WinterizingFreshwater SystemThe entire freshwater system must be completely drained. Disconnect all hoses, check valves, etc.and blow

2460 DenaliBilgeCoat all metal components, wire busses, and connector plugs in the bilge with a protecting oil. Itis also important to protect all str

2460 DenaliOWNER'S/OPERATOR'SRESPONSIBILITIESviRegistration and NumberingFederal law requires that all undocumented vessels equipped with pr

2460 DenaliBEFORE LAUNCHING THE BOAT, MAKE SURE THE DRAIN PLUG IS INSTALLED.Reactivating The Boat After Storage• Charge and install the batteries.• In

2460 Denali15-1Chapter 15:SCHEMATICS12-Volt Wiring Schematic

2460 DenaliSteering SystemSteering CableSteering CylinderHelmPower SteeringPump15-2

2460 DenaliFuel SystemFuel FilterFuel TankFuel FillFuel VentAnti-SiphonValve15-3

2460 DenaliRaw Water System(W\O Y-Valve and Macerator)15-4

2460 DenaliHead System (With Y-Valve)15-5

2460 DenaliHeadS System (With Y-Valve and Macerator)15-6

2460 DenaliFreshwater System15-7

2460 DenaliDrainage SystemRope Locker DrainScuppersBaitwell DrainBaitwell OverflowBilge PumpCooler DrainCooler Drain15-8

2460 DenaliAppendix A:GLOSSARY OF TERMSAft: In, near, or toward the stern of a boat.Aground: A boat stuck on the bottom.Amidship: In or toward the

2460 DenaliOWNER'S/OPERATOR'SRESPONSIBILITIESeven for experienced boaters to sharpen your skills or bring you up to date on current rules an

2460 DenaliBoat Hook: Short shaft of wood or metal with a hook fitting at one end shaped to aid in extendingone’s reach from the side of the boat.Bow

2460 DenaliDeck: The floor-like platform of a boat that covers the hull.Displacement: The volume of water displaced by the hull. The displacement w

2460 DenaliGround Tackle: A general term including anchors, lines, and other gear used in anchoring.Grounds: A boat touches the bottom.Gunwale: The

2460 DenaliLimber Hole: A passage cut into the lower edges of floors and frames next to the keel to allowbilge water to flow to the lowest point of t

2460 DenaliPitch: The measure of the angle of a propeller blade. Refers to the theoretical distance the boattravels with each revolution of the prop

2460 DenaliSeacock: Safety valves installed just inside the thru-hull fittings and ahead of the piping or hoserunning from the fittings.Shaft log: P

2460 DenaliTaffrail: Rail around the rear of the cockpit.Thru-hull: A fitting used to pass fluids (usually water) through the hull surface, either a

2460 DenaliHoursDate Dealer Service/RepairsMAINTENANCE LOGAppendix B:B-1

2460 DenaliHoursDate Dealer Service/RepairsB-2MAINTENANCE LOG

2460 DenaliHoursDate Dealer Service/RepairsMAINTENANCE LOGB-3

2460 DenaliviiiTABLE OF CONTENTSChapter 1: Propulsion SystemPage1.1 General ...

2460 DenaliHoursDate Dealer Service/RepairsMAINTENANCE LOGB-4

2460 DenaliHoursDate Dealer Service/RepairsMAINTENANCE LOGB-5

2460 DenaliHoursDate DealerService/RepairsMAINTENANCE LOGB-6

2460 DenaliAppendix C:C-1BOATING ACCIDENT REPORTFORM APPROVEDOMB NO.211-0010DEPARTMENT OFTRANSPORTATIONU.S. COAST GUARDC.G. 1865 (REV. 1/88)The operat

2460 DenaliC-2If more than 3 fatalities and/or injuries, attach additional form(s)WAS VICTIM?[ ] Swimmer[ ] Non SwimmerDATE OFBIRTHADDRESSNAME DEATH

2460 DenaliContentsDEAR PURSUIT DENALI OWNER:SAFETY INFORMATIONBOAT INFORMATIONIMPORTANT INFORMATIONOWNER'S/OPERATOR'S RESPONSIBILITIESTAB

2460 DenaliChapter 5:FRESHWATER SYSTEM5.1 General5.2 Freshwater System Operation5.3 Freshwater System MaintenanceChapter 6:RAW WATER SYSTEM6.1 Gener

2460 DenaliChapter 10:OPERATION10.1 General10.2 Rules of the Road10.3 Pre-Cruise System Check10.4 Operating Your Boat10.5 Water Skiing10.6 Fishing10.

2460 DenaliHeadS System (With Y-Valve and Macerator)Freshwater SystemDrainage SystemAppendix A:GLOSSARY OF TERMSAppendix B:MAINTENANCE LOGAppendix C:

2460 DenaliTABLE OF CONTENTSChapter 4: Electrical SystemPage4.1 General ...

2460 DenaliTABLE OF CONTENTSChapter 8: Ventilation SystemPage8.1 Cabin Ventilation ...8-1

2460 DenaliTABLE OF CONTENTSChapter 11: Exterior EquipmentPage11.1 Deck ...

2460 DenaliTABLE OF CONTENTSChapter 15: SchematicsPage12-volt DC Wiring Schematic ...15-1Steerin

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter 1:PROPULSION SYSTEM1.1 GeneralThe 2460 Denali is designed to be powered with a single inboard/outboard engine and drivesystem. Eac

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliUSE ONLY CLEAN, DRY FUEL OF THE TYPE AND GRADE RECOMMENDED BY THE EN-GINE MANUFACTURER. THE USE OF INCORRECT OR CONTAMINATED FUEL CANCAUSE

2460 Denalibe replaced more often. For recommendations regarding corrosion protection for the engine oroutdrive, please refer to the engine owner’s m

2460 DenaliFreshwater Cooling (Optional)Installation of “Freshwater Cooling” provides adequate engine cooling without exposing theinternal engine coo

2460 Denali1.6 Engine InstrumentationThe helm station is equipped with a set of engineinstruments and/or alarms. These instruments allowthe pilot to

2460 DenaliOPERATION OF AN ENGINE WITH ABNORMALLY LOW, OR HIGH, OIL PRESSURE CANLEAD TO ENGINE DAMAGE AND POSSIBLE SEIZURE. HAVE THE ENGINE SERVICEDI

2460 Denali1-7Depth GaugeThe depth gauge indicates the depth of the water below the bottom of the boat.Instruments MaintenanceElectrical protection fo

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter 2:HELM CONTROL SYSTEMS2.1 GeneralThe helm controls consist of the following: enginethrottle and shift controls, the steering syste

2460 Denali2.3 Neutral Safety SwitchEvery control system has a neutral safety switch incorporated into it. This device prohibits theengine from being

2460 Denali2.5 Outdrive Power Tilt and TrimAll inboard/outboard drive systems have a tilt and trim featurefor the outdrive. This allows the operator

2460 DenaliDear Pursuit Denali Owner:All of us at Pursuit are pleased that you have selected one of our products as yourboat. As I’m sure you’ve disc

2460 Denali2.7 Trim TabsThe 2460 Denali uses a dual toggle switch to control the trimtabs. The switch is labeled and controls bow up and downmovement

2460 Denali2.8 Control Systems MaintenanceControl MaintenancePeriodic inspection of the control systems and all connections should be made. Signs of

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter 3:FUEL SYSTEM3.1 GeneralThe gasoline fuel system used in Pursuit boats is designed to meet or exceed the requirements ofthe U.S.

2460 DenaliFuel Withdrawal TubesThe fuel withdrawal tube is positioned in the fuel tank to achieve optimum fuel usage, fuel linerouting, etc. At cert

2460 Denali3.2 Inboard/Outboard Fuel SystemThe fuel system on the 2460 Denali has one fuel tank. The fuel tank is mounted in the center ofthe bilge a

2460 Denali3.3 Fueling InstructionsFUEL IS VERY FLAMMABLE. BE CAREFUL WHEN FILLING THE FUEL TANKS. NOSMOKING. NEVER FILL THE TANKS WHILE THE ENGINE

2460 DenaliSPILLED FUEL IS DANGEROUS AND CAN YELLOW FIBERGLASS OR IGNITE. MAKE SUREYOU DO NOT SPILL ANY FUEL. IF FUEL IS SPILLED ON THE DECK, USE A

2460 Denali3.4 Fuel System MaintenancePeriodically inspect all connections, clamps and hoses for leakage and damage or deterioration.Replace as necess

2460 DenaliAFTER THE FILTER ELEMENT HAS BEEN CHANGED, PRIME THE FUEL SYSTEM ANDCHECK ALL FITTINGS FOR LEAKS BEFORE AND AFTER STARTING THE ENGINE.BEFOR

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter 4:ELECTRICAL SYSTEM4.1 GeneralYour Denali is equipped with a 12-volt DC electrical system and a 110-volt AC system. The ACsystem

2460 DenaliFor example: When the switch is on battery # 1, the engine and the 12-volt system will be suppliedpower by battery # 1. Battery # 2 will

2460 DenaliNote: Please refer to the DANGER and CAUTION notations in the Ventilation SystemsChapter 8.Bilge PumpThe bilge pump is installed in the cen

2460 DenaliElectronics SwitchThis switch supplies 12-volt electrical current to the electronics.12-volt ReceptacleProvides electrical current for port

2460 DenaliCheck the electrolyte level in the batteries regularly and add distilled water as necessary. If thebatteries are frequently charged by an

2460 Denali4-6THIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter 5:FRESHWATER SYSTEM5.1 GeneralThe freshwater system consists of a potable water tank, distribution lines and a distribution pump.T

2460 Denali5.2 Freshwater System OperationFill the water supply tank slowly through the labeled deck plate.After filling the water tank, partially ope

2460 Denali5-3THE BATTERIES MUST BE PROPERLY CHARGED. OPERATING THE FRESHWATER PUMPFROM A BATTERY WITH A LOW CHARGE MAY LEAD TO A PUMP FAILURE.THE FR

2460 DenaliiiSAFETY INFORMATIONYour Denali Owner’s Manual has been writtento include a number of safety instructions to assure the safeoperation and

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter 6:RAW WATER SYSTEM6.1 GeneralIn the raw or sea water systems, all water pumps are supplied by a hose connected to a ball valveand

2460 Denali6.2 High Pressure WashdownA saltwater high pressure pump, controlled by a pressure sensor, supplies the raw water hoseconnector located in

2460 Denali6.3 Livewell (Optional)Sea water is provided to the livewell by a 12-volt circulationpump. This pump is designed to carry a constant flow

2460 Denali6.4 Raw Water System MaintenanceThe following items should be done routinely to help maintain your raw water system.• Check hoses, particul

2460 DenaliChapter 7:DRAINAGE SYSTEMS7.1 Cockpit DrainsYour Denali has two scupper drains located on each side of thehull, near the waterline, to pr

2460 Denali7.3 Bilge DrainageThe bilge pump is activated both manually, bya switch in the helm station, and automaticallyby a float switch built into

2460 Denali7.5 Water System DrainsAll sinks and livewells, provided with fresh or raw water, drain by gravity to overboard thru hullslocated in the hu

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter 8:VENTILATION SYSTEM8.1 Cabin VentilationVentilation to the cabin areas is provided by a deck hatch and louvers inthe cabin doors.

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 Denali8.3 Engine Compartment VentilationAll Pursuit inboard/outboard boats are equipped withengine compartment ventilation. The ventilation sys-

2460 Denali8.4 Carbon Monoxide and VentilationFAILURE TO PROPERLY VENTILATE THE BOAT WHILE THE ENGINE IS RUNNING MAYPERMIT CARBON MONOXIDE TO ACCUMULA

2460 DenaliACTUATION OF THE CARBON MONOXIDE DETECTOR INDICATES THE PRESENCE OFCARBON MONOXIDE (CO) WHICH CAN BE FATAL. EVACUATE THE CABIN IMMEDI-ATEL

2460 DenaliChapter 9:SAFETY EQUIPMENT9.1 GeneralYour boat and inboard/outboard engines have been equipped with safety equipment designed toenhance th

2460 Denali9.3 Neutral Safety SwitchEvery control system has a neutral safety switch incorporated into it. This device prohibits theengine from being

2460 DenaliVisual Distress SignalsAll Pursuit boats used on coastal waters, the Great Lakes, territorial seas, and those watersconnected directly to t

2460 DenaliFire ExtinguishersAt least one fire extinguisher is required on all Pursuit boats. Coast Guard approved fireextinguishers are hand-portabl

2460 Denali9.6 Automatic Fire Extinguishing SystemThe Denali engine compartment is equipped with an optional automatic fire extinguishing system.The e

2460 Denali9.7 Carbon Monoxide Monitoring SystemCARBON MONOXIDE IS A LETHAL, TOXIC GAS THAT IS COLORLESS AND ODORLESS.IT IS A DANGEROUS GAS THAT WILL

2460 DenaliPersons who have been exposed to carbon monoxide should be moved into fresh air immediately.Have the victim breath deeply and seek immediat

2460 DenaliiiiBOAT INFORMATIONMAKE:SERIAL #:MODEL:GVRW:PHONE:REPRESENTATIVE:TRAILERNAME:DEALER/PHONE:ADDRESS:SERVICE MANAGER:ADDRESS:SALESMAN:DEALER

2460 DenaliYour boat should also be equipped with at least a simple marine first-aid kit and a first-aid manual.The first-aid kit should be designed f

2460 Denali9.10 Maximum Capacity RatingYour boat could be equipped with a “Maximum Capacities” plate, which is permanently attachedto the cockpit nea

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter 10:OPERATION10.1 GeneralBefore you start the engine on your Denali, you should have become familiar with the variouscomponent sys

2460 DenaliNote: Sailboats not under power, paddle boats and other vessels without power have theright of way over motor powered boats. You must stay

2460 Denali10.3 Pre-Cruise System CheckBefore Starting the Engine:• Check the weather forecast. Decide if the planned cruise can be made safely.• Be

2460 Denali• Have a tool kit aboard. The kit should include the following basic tools:Spark Plug Wrench HammerSpark Plug Gap Gauge Electrician’s Tape

2460 Denali• Check the engine gauges. Make sure they are reading normally.• Check the controls for proper operation.• Make sure all lines, cables, an

2460 Denali• Before operating the boat for the first time, read the engine break-in procedures. The break-in procedures are found in the owner’s manu

2460 DenaliTO PREVENT DAMAGE TO THE BOAT, CLOSE ALL SEACOCKS BEFORE LEAVING THEBOAT.10.5 Water SkiingYour Denali could be equipped for water skiing.

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 Denali10.6 FishingFishing can be very exciting and distracting for the operator when the action gets intense. You mustalways be conscious of the

2460 DenaliRUNNING AGROUND OR STRIKING AN UNDERWATER OBSTRUCTION CAN RESULT IN SE-RIOUS INJURY TO PASSENGERS AND DAMAGE TO THE MOTOR OR BOAT. IF YOUR

2460 Denali• Make sure the trailer bunks and rollers properly support the hull and do not put pressure on thelifting strakes. The rollers and bunks m

2460 Denali• CHECK THE BRAKES. On a level parking area roll forward and apply the brakes severaltimes at increasing speeds to determine if the brakes

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter 11:EXTERIOR EQUIPMENT11.1 DeckRails and Deck HardwareThe rail system and hardware fittings have been selected and installed to per

2460 DenaliStainless Steel Bow RollerThe bow roller assembly is recessed and allows the anchorto be operated and stored at the roller. The roller is

2460 DenaliDO NOT USE A WINDLASS AS A SOLE MEANS OF SECURING AN ANCHOR IN THE BOWROLLER. ALWAYS SECURE THE ANCHOR LINE TO A CLEAT OR ANCHOR CLASP BE-

2460 DenaliNote: Cold weather can make the clear vinyl material stiff and difficult to stretch to thesnaps. This can particularly difficult with new

2460 DenaliTrim TabsThe trim tabs are recessed into the hull below the swim platform. The trim tabs are an importantpart of the control systems. Ple

2460 DenaliWarranty and Warranty Registration CardsThe Denali Limited Warranty Statement is included with your boat. It has been written to be clear

2460 DenaliHelm SeatThe helm seat is a pedestal seat that swivels and adjusts fore and aft. There are two levers and onetension knob on the seat base

2460 DenaliFreshwater Sink and ShowerA freshwater sink is located in the rear of the cockpit next to the engine hatch. It is equipped withshower hea

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 DenaliChapter: 12INTERIOR EQUIPMENT12.1 Marine Head SystemThe 2460 Denali is equipped with china head and holding tank as standardequipment. The

2460 DenaliIN MANY AREAS IT IS ILLEGAL TO FLUSH HEAD WASTE DIRECTLY OVERBOARD. VIO-LATION OF THESE POLLUTION LAWS CAN RESULT IN FINES OR IMPRISONMENT

2460 Denaligasoline engines and auxiliary generators and propane or butane stoves. These produce largeamounts of CO and should never be operated whil

2460 DenaliTHIS PAGE WAS LEFT BLANKINTENTIONALLY

2460 Denali13-1Chapter 13:ROUTINE MAINTENANCE13.1 Exterior Hull and DeckHull Cleaning-Below The Water LineWhen the boat is removed from the water, cl

2460 DenaliWhen replacing the anodes, make sure the contact surfaces are clean, shinny metal and free of paintand corrosion. Never paint over the ano

2460 DenaliStainless Steel HardwareWhen using the boat in saltwater, the hardware should be washed with soap and water after eachuse. When your boat